山東通風管道?定時清洗的必要性？

發布人：http://rdhw.com.cn   發布時間：2020-04-08 11:48:44

隨著使用時間的增加，通風管道會積累大量的雜質。這些雜質會在管道中儲存很長時間，在操作過程中會加速油的凝結。溫度轉換過高，會對氣動閥、液壓等元件造成損壞，并對正常運行有很大影響。因此，定期對通風管道設備進行清洗是非常必要的。

　　With the increase of service time, a large amount of impurities will accumulate in the ventilation pipe. These impurities will be stored in the pipeline for a long time, which will accelerate the oil condensation during operation. Too high temperature conversion will damage the pneumatic valve, hydraulic and other components, and have a great impact on normal operation. Therefore, it is very necessary to clean the ventilation equipment regularly.

　　(1)風道與風機連接時，進、出口均應安裝軟接頭。軟接頭的截面尺寸應與風機進出口截面尺寸一致。軟管接頭可以由帆布、人造皮革和其他材料制成。軟管長度不應小于200，并應適當擰緊。軟管可以緩沖風扇的振動。

　　(1) When the air duct is connected with the fan, soft joints shall be installed at the inlet and outlet. The section size of soft joint shall be consistent with that of fan inlet and outlet. Hose connections can be made of canvas, artificial leather, and other materials. The hose length shall not be less than 200 and shall be properly tightened. The hose dampens the vibration of the fan.

　　(2)風道連接除塵設備和加熱設備時，設備安裝完畢后，按理論映射圖暫停預制。

　　(2) When the air duct is connected with the dedusting equipment and the heating equipment, the prefabrication shall be suspended according to the theoretical map after the installation of the equipment.

　　(3)安裝通風管道時，在預制管道時應將進、出口打開。如果需要在安裝結束時打開管道，則接口應緊密。

　　(3) When installing the ventilation pipe, the inlet and outlet shall be opened when prefabricating the pipe. If it is necessary to open the pipe at the end of installation, the interface shall be tight.

　　(4)輸送凝結水或含濕量大的氣體時，水平管道應呈斜坡?tīng)睿⒃诘吞幣c排水管道連接。安裝時，管道底部不應出現縱向接縫，底部接縫應懸掛密封處理。

　　(4) When transporting condensed water or gas with large moisture content, the horizontal pipeline shall be sloped and connected with the drainage pipeline at the low place. During installation, there shall be no longitudinal joint at the bottom of the pipeline, and the bottom joint shall be suspended for sealing.

　　(5)輸送易燃易爆氣體的鋼板風道，應在風道連接法蘭處安裝跳線，并與靜電地網連接。

　　(5) For the steel plate air duct conveying inflammable and explosive gas, the jumper shall be installed at the connecting flange of the air duct and connected with the electrostatic ground grid.

　　(6)水平風道高度大于4m時，安裝人員應系好帶。腳手架或活動支架上的板材應固定，板材的寬度應符合規范，腳手架上的設備人員應隨身攜帶包袋，避免物品或鉆頭等物品掉落傷及。

　　(6) When the height of horizontal air duct is more than 4m, the installation personnel shall fasten the safety belt. The plate on the scaffold or movable support shall be fixed, and the width of the plate shall conform to the safety specifications. The equipment personnel on the scaffold shall carry bags with them to avoid the falling of articles or drill bits and other articles.

　　(7)雙臂支撐在風道內就位后，橫臂應伸直，不應更換雙臂，雙臂受力均勻。

　　(7) After the double arms are supported in place in the air duct, the cross arms shall be extended, and the double arms shall not be replaced, and the force on the double arms shall be even.

　　每三個月清洗一次，既保證了風管的正常運行，又延長了風管的使用壽命。

　　Cleaning every three months not only ensures the normal operation of the air duct, but also extends the service life of the air duct.

　　以上就是對山東通風管道的清理的必要性的詳細介紹，想要了解更多請點擊官網http://rdhw.com.cn

　　The above is a detailed introduction to the necessity of cleaning the ventilation pipes in Shandong Province. For more information, please click http://rdhw.com.cn